广西快三走势图

行业新闻 您当前所在的位置:广西快三走势图 - 行业新闻

工业滤水器技术要求

发布:hydlfj 浏览:1503次

  工业滤水器技术要求

  3SHEJIHEYUNXINGTIAOJIAN

  3.1REWANGXUNHUANSHUISHUJU:

  REWANGHUISHUISHUIWEN:70℃

  REWANGHUISHUIGONGZUOYALI:0.2~0.5Mpa

  QUANCHANGREWANGXUNHUANSHUILIANG:4850t/h

广西快三走势图  3.2REWANGLVSHUIQISHUJU

  REWANGLVSHUIQIJINCHUKOUGUANDAOGUIGE:OD920X10(ZANDING)

广西快三走势图  REWANGLVSHUIQITAISHU:QUANCHANGGONG2TAI。

  REWANGXUNHUANSHUISHUIZHI:

  4LVSHUIQIJISHUYAOQIU

  4.1JIBENGUIGEHERONGLIANG

  4.1.1设备名称

  DIANDONGLVSHUIQI(REWANGXUNHUANSHUIZIDONGQINGXILVSHUIQI)

  4.1.2型式(或型号)及用途

广西快三走势图  XINGSHI(HUOXINGHAO):LISHI,REWANGSHUISHUIPINGJIN,SHUIPINGCHU。

广西快三走势图  YONGTU:YONGYUGUOLVHEQINGCHUREWANGXUNHUANSHUIZHONGDEWUWU。

广西快三走势图  4.1.3SHEBEICANSHU

  (1)出口直径:OD920X10

  (2)入口直径:OD920X10

  (3)型式:立式

  (4)水量:5340t/h

  (5)GONGZUOYALI:0.2~0.5MPa(ZANDING)

  (6)滤芯网孔:<2mm

  (7)运行水阻:≤1000mmH2O

  (8)电动机规范:380V/50Hz/IP54

广西快三走势图  (9)SHULIANG:QUANCHANG2TAI。

  (10)LVSHUIQIBUZHI

  QIJIFANGREWANGSHOUZHANLINGMICENG。

广西快三走势图  (11)SHEJIYALI:0.6MPa

  4.2设备性能要求

  4.2.1热网循环水电动滤水器的骨架、网芯应具有足够的强度,能在热网循环水0.15MPa的压差作用下正常工作。

  4.2.2广西快三走势图电动滤水器采用全自动的运行方式,在设计的循环水量下各设备的水阻都应满足4.1.3节中的要求。

  4.2.3广西快三走势图电动滤水器应具有自动反冲洗功能,滤网前后设压差测量系统,当前后压差不断增加达到设定值时,滤网自动进行反冲洗,同时还应有力矩保护、自动反转等功能。

  4.2.4广西快三走势图电动滤水器一次反冲洗时间小于5分钟,且一次清洗带走的水量应小于相应时间内额定流量的4%。

  4.2.5电动滤水器系统中阀门开启与关闭应灵活、方便。

  4.2.6电动滤水器滤网壳体设置人孔门,并保证网芯在局部破坏时只需通过人孔门单独进行更换或修理。

  4.2.7DIANDONGLVSHUIQIZHUANZIQUDONGJIGOUXINGSHIWEIDIANDONG,QIELVSHUIQIFANCHONGXIZHUANZIHAIYINGSHESHOUDONGKONGZHI。

  4.3SHEBEIZHIZAOYAOQIU

  4.3.1设备制造的加工和安装应符合图样及技术条件要求。

  4.3.2各部件表面、通道、孔眼均应平滑无毛刺。

广西快三走势图  4.3.3WAIGOUJIANDOUBIXUYOUCHANPINZHILIANGHEGEZHENG

广西快三走势图  4.4JIEGOUYAOQIU/XITONGPEIZHIYAOQIU

  4.4.1广西快三走势图电动滤水器的网芯等内部过流部件应为多片可单独拆卸或更换的结构。网眼无连孔、破孔等缺陷,并且应排列整齐。

  WAIQIAO、DUANGAI、JIEGUANCAIYONGTANGANGCAILIAO。

  4.4.2广西快三走势图滤网分成多个单位,分别采用螺栓固定在支撑板上,以避免由于长期冲刷造成焊点首先腐蚀而导致强度降低,甚至破坏。

  4.4.3卖方应详细说明电动滤水器的每个设备接口承受的力和力矩的限制。所有的设备包括其支座,都具有安全承受从用户连接管道接口传递来的力和力矩的能力,并且假定这些力和力矩同时发生作用。

广西快三走势图  4.4.4DIANDONGLVSHUIQIDEDIANDONGZHIXINGJIGOUYINGCAIYONGYOUCHENGSHUPEIHEJINGYAN、XINGNENGYOULIANGDECHANPIN,MAIFANGYINGZAIWENJIANZHONGYINGXIANGXISHUOMINGQICHANGJIA、CHANDIJIJUTICANSHU。YOUMAIFANGPEITAOTIGONGDEDIANDONGPAIWUFADEZHIXINGJIGOUYINGCAIYONGZHINENGYITIHUACHANPIN,JIDIANDONGZHIXINGJIGOUNEISHEYOUJIECHUQI、REJIDIANQIDENGPEIDIANSHEBEI,MAIFANGZHIXUTIGONG380VAC,50HZSANXIANGSIXIANZHIDONGLIDIANYUANHEKAI/GUANXINHAOJIUKEZHIJIEQUDONGFAMEN。MAIFANGANWENZHOURUIJIRXILIE;GUOCHANRotork;YANGZHOUDIANLIXIUZAOCHANGDENGSANJIACHANPINFENBIEBAOJIA,YOUZHAOBIAORENZUOZHONGQUEREN。JUTICHANGJIAZHONGYOUMAIFANGQUEREN。

  4.4.5TONGXINGHAOSHEBEIDELINGBUJIAN(BAOKUOBEIYONGPIN)DOUYINGSHIWANQUANKEYIHUHUANDE。

  4.4.6SHEBEICAIZHIYAOQIU

  4.4.6.1广西快三走势图设备主要零部件所用的钢材和焊接材料必须具有质量合格证书,或应符合相应的材料标准。

  4.4.6.2与水接触的所有零部件应采用耐腐蚀性能较好材料,并填入下表:

  REWANGXUNHUANSHUILVSHUIQICAILIAOBIAO

广西快三走势图  MAIFANGYINGXIANGXISHUOMINGGEBUJIANSUOCAIYONGDEFANGFUCUOSHI。

  4.4.6.3PEITAOFAMENQUANBUCAIYONGZHUGANGCAIZHI(PAIWUFACAIYONGZHUGANGCAIZHI).

  4.4.6.4SUOGONGSHEBEIYONGZHOUCHENGWEISKFRUIDIANJINKOUZHOUCHENG

广西快三走势图  4.4.6.5MIFENGCAIYONGJIXIEMIFENG.

  4.5PEIGONGDEFUZHUSHEBEIYAOQIU

  4.5.1PEITAODIANDONGJIYAOQIU(RUGUOYOU)

广西快三走势图  4.5.1.1DIANDONGJIDESHEJIYUGOUZAO,BIXUYUDIANDONGLVSHUIQIDEYUNXINGTIAOJIANHEWEIHUYAOQIUXIANGYIZHI。DIANDONGJIDESHENGCHANCHANGSHANGWEIDIANJICHANG。

广西快三走势图  4.5.1.2DIANDONGJIDEEDINGDIANYAWEI380V,PINLVWEI50Hz。DANGPINLVWEIEDING,QIEDIANYUANDIANYAYUEDINGZHIDEPIANCHABUCHAOGUO±10%SHI,DIANDONGJIYINGNENGSHUCHUEDINGGONGLV,DANGDIANYAWEIEDING,QIEDIANYUANPINLVYUEDINGZHIDEPIANCHABUCHAOGUO±1%SHI,DIANDONGJIYINGNENGSHUCHUEDINGGONGLV。

  4.5.1.3DIANDONGJIYINGBAOZHENGZAI80%EDINGDIANYAXIAPINGWENQIDONG,QIENENGZAI55%EDINGDIANYAXIAZIQIDONG。DIANDONGJIYINGNENGCHENGSHOUDIANYUANKUAISUQIEHUANGUOCHENGZHONGSHIDIANERBUSHOUSUNHUAI,BINGJIADINGDIANDONGJIZAIQIEHUANQIANSHIMANZAIYUNXING。

广西快三走势图  4.5.1.4DIANDONGJIQIDONGDIANLIUBEISHUBUDAYU6.5BEIEDINGDIANLIU。

广西快三走势图  4.5.1.5DIANDONGJIFANGHUDENGJIWEIIP54,QIJUEYUANDENGJIWEIFJI,BINGYIBJIWENSHENGKAOHE。

  4.5.2PEITAOJIANSUJIYAOQIU(RUGUOYOU)

  所有配套减速机应采用中硬齿面或硬齿面减速机,卖方应在文件中说明减速机的形式,减速机的配套厂商由卖方推荐3个厂商,终厂商的选择由买方确认。

  4.6仪表和控制要求

广西快三走势图  4.6.1MAIFANGSUIDIANDONGLVWANGPEIGONGYITAOYONGYISHIXIANXITONG(BAOKUODIANDONGLVWANG、PAIWU、FANCHONGXIDENG)ZIDONGYUNXINGSUOXUDEWANZHENGDEJIANCEYIBIAO、KONGZHIZHUANGZHI、LIANJIEDIANLANHEANZHUANGFUJIANDENG。SUOYOUCHENGTAOTIGONGDEJIUDICELIANGYIBIAOYINGPEIGONGXIANGYINGDEANZHUANGFUJIAN(YICIMEN、ERCIMEN、PAIWUMENJIXIANGYINGDECELIANGDAOGUANDENG)。

广西快三走势图  4.6.2MAIFANGTIGONGDEKONGZHIZHUANGZHISHANGYINGYOUDUISHEBEIJINXINGDANGECAOZUO、SHOUDONG/ZIDONGKONGZHIFANGSHIZHUANHUANHEYUANFANG/JIUDIQIDONGFANGSHIZHUANHUANDECAOZUOSHOUDUAN。

广西快三走势图  4.6.3MAIFANGTIGONGDEKONGZHIZHUANGZHIYIFANGHUDENGJIIP56(FANGFU)DEXIANGTIFANGSHITIGONG,BINGANZHUANGYUSHEBEIPANG,KONGZHIZHUANGZHIYUSHEBEIBENTI、JIANCEYIBIAOZHIJIANDESUOYOULIANJIEDIANLANHEJIEXIAN、DIANLANMAIGUANFUSHEYOUMAIFANGTIGONG。MAIFANGJINFUZETIGONG380VACSANXIANGSIXIANZHIDIANYUANZHIMAIFANGKONGZHIJUDUANZIPAI,RUOXUYAOQITADENGJIDIANYUAN,YOUMAIFANGZIXINGZHUANHUAN。KONGZHIXIANGNEIDIANQIYUANJIAN、KONGZHIQIHEXIANGMIANKONGZHIANNIUCAIYONGJINKOUYOUZHICHANPIN。KONGZHIJUDESEBIAOYOUMAIFANGZHONGQUEREN。

广西快三走势图  4.6.4SUISHEBEITIGONGDEJIUDIKONGZHIZHUANGZHIYINGBAOZHENGGENJULVWANGQIANHOUDECHAYAZIDONGSHIXIANCHONGXIDEGONGNENG,BINGYINGLIUYOUMAIFANGDCSKONGZHIXITONGDUIDIANDONGLVWANGJINXINGJIANSHIHECAOZUODEJIEKOU,JIEKOUDIANZAIMAIFANGKONGZHIJUDEDUANZIPAISHANG。JIEKOUXINHAOXINGSHIWEIWUYUANJIEDIAN,JIEDIANRONGLIANG220VAC5A,HUO220VDC1A。

广西快三走势图  4.6.5MAIFANGKONGZHIZHUANGZHIJIESHOUMAIFANGDCSDEZHILINGXINHAORUXIA:

  ――QIDONGZHILING

  ――TINGZHIZHILING。

广西快三走势图  4.6.6MAIFANGKONGZHIZHUANGZHIXIANGMAIFANGDCSFANKUIDEXINHAORUXIA:

  ――YUNXINGZHUANGTAI;

  ――DIANDONGXUANZHUANLVWANGGUZHANG(ZONGHEXINHAO);

  ――LVWANGQIANHOUCHAYAGAO;

广西快三走势图  ――PAIWUMENKAIZHUANGTAI;

  ――PAIWUMENGUANZHUANGTAI。

  ――XITONGYUANFANG/JIUDIZHUANGTAI。

  4.6.7SUOYOUYONGYUYUANFANGZHISHI、BAOJING、KONGZHISUOYONGDEXINHAOYINGJIEZHIJIUDIKONGZHIZHUANGZHIDEJIEXIANDUANZIPAISHANG,GONGMAIFANGSHIYONG。

  4.6.8SUIBENTIGONGHUODEYIBIAOHEKONGZHISHEBEI,YINGXUANYONGTONGYONGCHANPIN,BINGFUHEGUOJIADEYOUGUANGUIDINGJIBIAOZHUN。SUOPEITAOGONGYINGDEYIBIAOHEKONGZHISHEBEIDEXUANXINGXUYOUMAIFANGRENKE,ZHEIXIEYIBIAOHEKONGZHISHEBEIYINGANQUAN、KEKAO,BINGYINGYUQUANCHANGREKONGSHEBEIXUANXINGXIANGYIZHI,YUXUFANGZHENGTISHEJIFANGANXIANGXIEDIAO。SUOYOUXIANCHANGJIUDIYIBIAOSHEBEIMANZUIP56FANGHUDENGJI。

  4.6.9SUIBENTIGONGHUODEJIUDIYALIBIAOYINGZHUANGZAIBIANYUGUANCHAHEWEIXIUDEDIFANG,QIZHONGJIUDIYALIBIAODEJINGDUWEI1.5JI,BIAOPANZHIJING100mm;JIUDISHUANGJINSHUWENDUJI,BIAOPANZHIJING100mm。SUOGONGYIBIAOKEDUYINGCAIYONGIECGUOJIBIAOZHUN。

广西快三走势图  4.6.10MAIFANGTIGONGDEGUOCHENGLUOJIKAIGUANCAIYONGANJINKOUSOR、UE、ITTCHANPIN。ZHONGXUANXINGYOUMAIFANGQUEDING。

  4.6.11SUOYOUKAIGUANXINGDIANDONGFAMENDEDIANDONGZHUANGZHIYINGCAIYONGZHINENGYITIHUACHANPIN,JI:DIANDONGZHUANGZHINEIZHUANGSHEYOUJIECHUQI、REJIDIANQIDENGPEIDIANSHEBEI,SUOYOUDIAOJIEFADIANDONGZHUANGZHIYINGCAIYONGLUOTUOKEXILIECHANPIN,CAIGOUDESUOYOUFAMENXUDEDAOMAIFANGDERENKE,MAIFANGZHIXUTIGONG380VDONGLIDIANYUANHEKAI/GUANXINHAOJIUKEQUDONGFAMEN。

  4.6.12MAIFANGTIGONGDESUOYOUYIBIAOJIKONGZHISHEBEINENGMANZUDIANCHANGHUANJINGDEYAOQIU。

  4.7SHEBEIJISHUHEJIEGOUTEDIAN

  4.8广西快三走势图标准(卖方应详细列出制造、设计、加工产品所引/采用的标准和规范,并补充下述标准)

  GB1220-84不锈钢棒

  GB2100-80不锈耐酸钢铸件技术条件

  GB3077-88合金结构钢技术条件

  GB9113-88整体钢制管法兰

  GB9115-88对焊钢制法兰

  GB755旋转电机基本技术要求

  GB997电机结构及安装型式代号

  GB1993旋转电机冷却方法

  GB4942电机外壳保护等级

  4.9性能保证值

广西快三走势图  MAIFANGYINGANBENGUIFANSHUDEYAOQIU,BAOZHENGSHEBEIDEXIALIEXINGNENG:

  正常运行水阻10kPa

  DIANDONGLVSHUIQIYINGNENGYOUXIAODECHULIXUNHUANSHUIZHONGDEWUWU,YUNXINGPINGWENKEKAO,BINGSHIXIANZIDONG。

广西快三走势图  SHEBEIDESHIYONGSHOUMINGBUSHAOYU30NIANYISHANG。

广西快三走势图  5JIANZAO(JIANYAN)HEXINGNENGYANSHOUSHIYAN

广西快三走势图  JIANFUJIAN5:JIANZAO(JIANYAN)HEXINGNENGYANSHOUSHIYAN

  6设计与供货界限及接口规则

广西快三走势图  DIANDONGLVSHUIQIJINCHUKOUFALAN(BAOKUOFANFALANHELIANJIEFUJIAN)ZHIJIANDEBENTIJIFUSHUSHEBEI。DONGLIDIANYUAN、KONGZHIDIANYUANYOUMAIFANGFUZETIGONG。GONGHUOBAOKUOFALANJIEKOUDEFANFALANJIQILIANJIEJIAN,FALANLIANJIEJIANBAOKUOLUOSHUAN、LUOMU、DIANPIANDENG。

  7清洁,油漆,包装,装卸,运输与储存

  7.1QINGJIEHEYOUQI

广西快三走势图  ZUZHUANGQIANYINGCONGMEIGELINGBUJIANNEIBUQINGCHUQUANBUJIAGONGLAJI,RUJINSHUQIEXUE、TIANCHONGWUDENG,YINGCONGNEIWAIBIAOMIANQINGCHUSUOYOUYAXIE、XIUPIYOUZHIDENG。GANGJIEGOUZAIDIYICITUCENGQIANYINGZUOPENWANCHULI。YOUQIDEXUANZEYINGNENGSHIYINGYUNXINGHUANJINGTIAOJIAN。SUOYOUTANGANGHEDIHEJINGANGWAIBIAOMIANYAOYONGPENSHACHULIYOUQICHULI。MAIFANGYINGSHUOMINGZHEIXIETULIAODEMINGCHENG、ZHIZAOCHANGJIA、XINGHAOYIJIYONGYIQINGCHUZHEIXIETULIAODEHUAHEWUMINGCHENGHESHIYONGFANGFA。

  设备出厂前应喷涂二层底三层面漆,油漆颜色为色。(由买方确定)

  MAIFANGYINGXUANZEHAODETUCENGTUFUFANGSHI,YIFANGZHISHEBEIZAIYUNSHU、CHUCUNQIJIANBUBEIFUSHI。

  7.2BAOZHUANG﹑YUNSHU

  7.2.1SHEBEIDEBAOZHUANGYINGFUHEGB/T13384BIAOZHUNDEGUIDING,BINGCAIQUFANGYU﹑FANGCHAO﹑FANGXIU﹑FANGZHENDENGCUOSHI,YIMIANZAIYUNSHUGUOCHENGZHONG,YOUYUZHENDONGHEPENGZHUANGYINQIZHOUCHENGDENGBUJIANDESUNHUAI。SHEBEICHUCHANGSHI,LINGBUJIANDEBAOZHUANGFUHEJB2647DEGUIDING,FENLEIZHUANGXIANG,ZUNXUNSHIYUYUNSHU、BIANYUANZHUANGHECHAZHAODEYUANZE。

广西快三走势图  7.2.2SHEBEIFAYUNQIAN,YINGJIANGSHUIQUANBUFANGDIAOBINGCHUIGAN,MAIFANGYINGQUEBAOZHEIXIEBUJIANZAIFAYUNQIANZHONGXINZHUANGHAO。SUOYOUKAIKOU﹑FALAN﹑JIETOUYINGCAIQUBAOHUCUOSHI,YIFANGZHIZAIYUNSHUHECHUCUNQIJIANZAOSHOUFUSHI﹑SUNSHANGJIJINRUZAWU。SHEBEIDEJINCHUKOU﹑GUANKONGYINGYONGGAIBANFENGBI。XUYAOXIANCHANGLIANJIEDELUOWENKONGHUOGUANZUODEHANJIEKONGYINGCAIYONGLUOWENHUOQITAFANGSHIYUYIBAOHU。ZHEGAIWU﹑JINGUJIANBUYINGHANZAISHEBEISHANG。

广西快三走势图  7.2.3SHEBEIBIAOZHI

  7.2.3.1YINGZAISHEBEIMINGXIANBUWEIZHUANGSHENAIFUSHICAILIAOZHIZUODEBUXIUGANGJINSHUMINGPAI,JINSHUMINGPAIZHISHAOYINGBAOKUOYIXIANEIRONG:SHEBEIMINGCHENG、SHEBEIZHIZAOCHANGMINGCHENG、SHEBEIZHIZAONIANYUE、ZHIZAOCHANGCHANPINBIANHAO、ZHIZAOXUKEZHENGBIANHAO、SHEBEIXINGHAO、SHEBEIZHUYAOCANSHUDENG。

广西快三走势图  7.2.3.2MINGPAIYINGANFANGZAIYUNXINGRENYUANRONGYIKANDAODEDIFANG。

  7.2.3.3SHEBEIKKSBIAOSHI

  7.3YUNSHUYUCHUCUN

  DABUJIANCHICUNBIAOGEJIANFUJIAN9。CHUCUNYAOQIUCANJIANGUOJIAYOUGUANBIAOZHUN。

  MAIFANGTOUBIAOSHITIGONGBAOZHUANGBIAOZHUNJISHIYITU。